back

Please see Tech Tip T-TT-0662-21 APPLICABLE VEHICLES: 2020-2022 Highlander 2021-2022 Mirai 2021-2022 Venza HV 2020-2022 Highlander HV CONDITION: Some 2020-2022 model year Highlander and Highlander HV, 2021-2022 model year Venza HV and Mirai vehicles equipped with Premium Audio System with...

If you run across a 2019 Toyota (in this case a Camry but also Rav 4) that the radio starts rebooting over and over. Make sure that the radio software is up to date, disconnect the battery for half hour and then if that fails, put the key in, set the parking brake, engine off and put it in...

Please see T-SB-0041-21 Applicability: 2019 Prius Prime WMI(s): JTD VDS(s): KARFP 2019 - 2020 Prius WMI(s): JTD VDS(s): KARFU 2019 - 2020 RAV4, RAV4 HV WMI(s): 2T3, 4T3, JTM VDS(s): A1RFV, C1RFV, D1RFV, DWRFV, EWRFV, J1RFV, N1RFV, P1RFV, R1RFV, RWRFV, W1RFV, Y1RFV (Please see this Post to...

Please see T-SB-0116-20 Revision 2 (Link Needed) Introduction: Some 2018 – 2020 model year Camry and Camry Hybrid vehicles may exhibit the weatherstrip on the panoramic roof center glass peeling on the edges of the glass. Follow the Repair Procedure in this bulletin to address this...

Please see T-SB-0042-20 Revision 1 Applicability: 2018-2020 Toyota Sequoia and Tundra VDS(s): AY5F1, DY5F1, FY5F1, GY5F1, HY5F1 (Please see this Post to determine VDS) REVISION NOTICE February 03, 2022 Rev1: The Production Change Information and Warranty sections have been updated. Any...

Please see T-TT-0626-20 APPLICABLE VEHICLES: 2021 Toyota Venza, Venza Hybrid CONDITION: Some 2021 model year Venza customers/dealers may experience a condition where the front door window glass can easily be scratched when an abrasive product is used to clean the windows. RECOMMENDATIONS: The...

SEE Tech Tip T-TT-0512-18 CONDITION: On 2018-2019 model year Camry and 2019 model year Avalon, equipped with the 2GR-FKS engine, technicians may observe that the bank 1 (rear) exhaust manifold may be “missing” a stud and nut. The repair manual shows that, as per design intent, the exhaust...

Recall Letter You can check the status of any Recall on your Toyota here. On August 6, 2019, Toyota filed a Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA) informing the agency of our intent to conduct a voluntary Safety (Noncompliance)...

Some 2007 – 2020 model year Tundra (Crew Max) vehicles may exhibit a rust or perforation condition on the vehicle’s body behind the back window moulding. Follow the Repair Procedure in bulletin T-SB-0150-19 to address this condition. The fix is to verify the corrosion and then sublet the repair...

Please see T-SB-0149-19 Revision 2 (Link Needed) REVISION NOTICE: May 09, 2022 Rev2: Applicability has been updated to include 2022 model year Prius Prime vehicles. The Introduction, Production Change Information, Warranty Information, Parts Information, and Repair Procedure sections have...

Some 2013 – 2018 model year RAV4 and 2016 – 2018 model year RAV4 Hybrid vehicles may exhibit a condition in which the power back door makes a squeak noise when the door is opening or closing. Follow the Repair Procedure in bulletin T-SB-0004-19 to address this condition. R & R Power Back Door...

Some 2014 – 2018 model year Highlander and Highlander HV vehicles may exhibit a condition where the power back door (PBD) makes a squeak noise while the door is opening or closing. Follow the Repair Procedure in bulletin T-SB-0127-18 to address this condition. This repair is covered under the...

Some 2013 – 2017 model year RAV4 vehicles may exhibit corrosion around the rear hatch hinges. The corrosion may be present in varying degrees, ranging from paint blisters to red surface rust with perforation. Follow the Repair Procedure in bulletin T-SB-0120-18 to address this condition. This...

If you have a 2005 4Runner with code B2221 and the rear hatch window will not operate, you may want to disconnect the key switch connector on the hatch and then retry. The key tumbler has an electric switch to operate the window and can go bad causing this condition. Simply disconnect the switch...

Some 2013 – 2017 model year RAV4 and 2016 – 2017 model year RAV4 HV vehicles may exhibit a condition in which the LH or RH power back door actuator (power back door unit assembly set) separates from the ball mount bracket (back door damper stay bracket) on the hatch or body side. Additionally...

Some 2014 – 2016 model year Tundra vehicles may exhibit difficulty in adjusting seat position (forward or backward) on manual seats. This is due to the seat position adjustment lever interfering with the seat cushion. Follow the Repair Procedure in bulletin 0206-17 to address this condition...

Some 2016 – 2018 model year RAV4 vehicles equipped with a 2AR-FE engine may exhibit a rocking (back and forth) motion when utilizing the vehicle’s cruise control between 55 and 75 mph while driving on a flat and straight freeway/highway. The Engine Control Module/ECM (SAE Term: Powertrain...

Warranty Enhancement Letter ZG4 Subject: 2008 – 2013 Model Year Highlander and Highlander Hybrid Vehicles Extension of Warranty Coverage for the Power Back Door In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend...

Limited Service Campaign Letter G0X Subject: Limited Service Campaign G0X 2016 Model Year RAV4 and RAV4 Hybrid Vehicles Power Back Door ECU Replacement Condition: In the subject vehicles the power function of the back door could become inoperative if there is interference with an object while...