corrosion

If you run across a 2016ish (+,-) Toyota Rav4 and its blowing the 7.5 amp ecu-ig no.3 fuse, them you may want to check the AD1 connector located under driver side headlight that would power the front bumper sonar sensors and millimeter wave radar if it was equipped. Check for corrosion causing...

If you have a 2019-2020 Toyota Tacoma come in with a Low Braking Power message on the dash, then you may want to check the IS3 connector located in the R/F kick panel for any signs of corrosion in that connector. The likely culprit is that the windshield washer fluid is wicking through the...

If you run across a 2011 Toyota Highlander with various problems like the combination meter, trans shifting, and even the radio, then please check the passenger side kick panel for any corroded connectors. This would be due to water intrusion.

Please see T-SB-0018-21 (Link Needed) Applicability: 2007-2021 Toyota Tundra Introduction: Some 2007 – 2021 model year Tundra vehicles exhibit corrosion on the side step brackets. Examples of the corrosion condition are shown below. A service kit has been developed to allow replacement of the...

*** This condition is now addressed in a Technical Service Bulletin *** Please see Tech Tip T-TT-0630-20 APPLICABLE VEHICLES: 2019-2020 RAV4 Hybrid CONDITION: Some 2019-2020 model year RAV4 HV vehicles may experience DTC codes P0AA649 / P1C8049. - P0AA649-Hybrid/EV Battery Voltage System...

Please see T-SB-0030-20 Applicability: 2007-2020 Toyota Tundra Introduction: Some 2007–2020 model year Tundra vehicles may exhibit corrosion or paint blistering on the front and/or rear lower door sill(s). Follow the Repair Procedure in T-SB-0030-20 bulletin to address this condition...

Please see Tech Tip T-TT-0496-18 APPLICABLE VEHICLES: 2014-2016 Highlander Hybrid 2014-2016 Highlander CONDITION: Vehicles may experience a MIL ON condition exhibiting codes P314A and/or P0C73 with evidence of water (corrosion) at the A9 inverter water pump connector. This condition may be...

LIMITED SERVICE CAMPAIGN K0D (Remedy Notice) Condition: Toyota has received reports regarding frame corrosion perforation on 2011 – 2017 model year Tacoma vehicles. In these reports, customers have indicated that vehicles operated in specific cold climate areas with high road salt usage may...

Please see T-SB-0149-19 Revision 2 (Link Needed) REVISION NOTICE: May 09, 2022 Rev2: Applicability has been updated to include 2022 model year Prius Prime vehicles. The Introduction, Production Change Information, Warranty Information, Parts Information, and Repair Procedure sections have...

You can check the status of any SSC on your Toyota here. Special Service Campaign Letter JSD 2011-2017 Model Year Tacoma Coverage for Vehicle Frame Corrosion Perforation CSP ZKA In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Customer Support...

Look for Corrosion at the fuel pump ecu connector. The fix it to replace the harness and ecu....

Some 2016 – 2019 model year Tacoma vehicles may exhibit corrosion or paint blistering on the front and/or rear lower door sill(s). Follow the Repair Procedure in bulletin T-SB-0021-19 to address this condition. This repair is covered under the Toyota Basic Warranty. This warranty is in effect...

Some 2013 – 2017 model year RAV4 vehicles may exhibit corrosion around the rear hatch hinges. The corrosion may be present in varying degrees, ranging from paint blisters to red surface rust with perforation. Follow the Repair Procedure in bulletin T-SB-0120-18 to address this condition. This...

If you have a 2007-2013 Toyota Fj Cruiser with a Stall or No start condition and some/all of these codes... P2103, C1201, P0607, P0451, P0102, P0113, P0121, P0120, P2135, P0037, P0118, P0123, P0125, P0453, P0057, P0328, P0333, P0010, P0020, P0035, P0343, P0348 and you may have an intermittent...

Warranty Enhancement Letter ZH9 www.toyotaframesettlement.com Subject: Warranty Enhancement Program ZH9 2008 Model Year Sequoia Extension of Warranty Coverage for Frame Corrosion In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty...

Warranty Enhancement Letter ZH7 www.toyotaframesettlement.com Subject: Warranty Enhancement Program ZH7 2007-2008 Model Year Tundra Extension of Warranty Coverage for Frame Corrosion In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty...

Remedy Letter Owner Letter You can check the status of any Recall on your Toyota here. On September 17, 2015, Toyota filed a Defect Information Report (DIR) with the National Highway Traffic Safety Administration (NHTSA) informing the agency of our intent to conduct a voluntary Safety Recall...

Limited Service Campaign Letter ESD Subject: Limited Service Campaign (LSC) ESD 2005-2008 Model Year Tacoma Vehicles Frame Inspection In 2014, Toyota announced and rolled out a Limited Service Campaign (LSC E0D) for certain 2005-2008 model year Toyota Tacoma vehicles currently registered in...