highlander

Please see Recall 22TA03 2020–2022 Toyota Models Vehicle Stability Control System May Not Default to "On" On April 26, 2022, Toyota amended a previously filed Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA). The amended Noncompliance...

Please see Tech Tip T-TT-0685-22 APPLICABLE VEHICLES: 2017-2022 Toyota Highlander 2017-2020 Toyota Sienna CONDITION: Some 2017-2022 Highlander, and 2017-2020 Sienna vehicles may experience an engine oil leak condition from the No.2 Oil pan. This issue is currently under investigation. Please...

Please see T-SB-0008-22 Applicability: 2020 - 2021 Highlander Hybrid Introduction: Some 2020 – 2021 model year Highlander Hybrid vehicles may exhibit one or more of the following conditions: * The fuel gauge displays less than full when the fuel nozzle automatically clicks off. * The total...

Please see SSC 21TC03 APPLICABLE VEHICLES: 2017 – 2019 Model Year Highlander Hybrid Vehicles 2018 – 2020 Model Year Camry Hybrid Vehicles 2019 Model Year Avalon Hybrid Vehicles 2019 Model Year Rav4 Hybrid Vehicles Condition: The subject vehicles are equipped with a low-pressure fuel pump which...

Please see T-SB-0105-11 Applicability: 2005 – 2011 Avalon 2007 – 2011 Camry, Sienna 2008 – 2011 Highlander 2006 – 2011 RAV4 2009 – 2011 Venza TSB SUPERSESSION NOTICE: The information contained in this TSB supersedes TSB Nos. EG002-08, EG003-08, and EG004-08. • Applicability has been updated to...

Please see SSC 21TC05 APPLICABLE VEHICLES: 2020-2021 Highlander (Non Hybrid ONLY) Condition: In the involved vehicles, the fuel gauge needle and the “distance to empty” estimated in the vehicle display accurately indicate the approximate amount of remaining fuel in the fuel tank. However...

Please see Tech Tip T-TT-0665-21 Revision 1 Also see Special Service Campaign SSC 21TC05 APPLICABLE VEHICLES: 2020-2021 Highlander Hybrid CONDITION: Special Service Campaign 21TC05 applies to the following condition: The fuel gauge needle and the “distance to empty” estimated in the vehicle...

If you run across a 2019 Toyota Highlander (possible Tundra also) with the radio and climate control panels go dark when the headlights are turned on, check the instrument cluster as the cause. These ground out through the instrument cluster so replacing it should solve this issue.

If you run across a 2017 Toyota Highlander with the Sirius XM button that has disappeared from the audio unit, then you might look towards the extension module located just below the radio as the cause. Sometimes unplugging it for 30 and then reconnect it will make the button reappear for a...

Please see T-SB-0201-11 Revision 1 *** This condition is now covered under Toyota Warranty called Limited Service Campaign (LSC) ZE2. Please see information here. Applicability: 2011 Highlander Hybrid 2008 – 2011 Highlander 2007 – 2011 Sienna 2009 – 2011 Venza REVISION NOTICE: November 21...

T-SB-0049-21 is Obsolete. Please see T-SB-0049-21 Revision 1 Applicability: 2020-2021 Toyota Highlander, Highlander Hybrid 2021 Toyota Sienna Hybrid Introduction: Some 2020 – 2021 Highlander and Highlander Hybrid and 2021 Sienna Hybrid vehicles may exhibit a MIL ON condition with Diagnostic...

Please see Tech Tip T-TT-0662-21 APPLICABLE VEHICLES: 2020-2022 Highlander 2021-2022 Mirai 2021-2022 Venza HV 2020-2022 Highlander HV CONDITION: Some 2020-2022 model year Highlander and Highlander HV, 2021-2022 model year Venza HV and Mirai vehicles equipped with Premium Audio System with...

There has been quite a few issues regarding Toyota Highlander Start and Stop batteries being available with some customers waiting a month or two to get them. Toyota has allowed the S95 battery to be used as a replacement for now (temporary solution). The new part number is 00544-24FEF-TS Also...

Please see Tech Tip T-TT-0657-21 (Link Needed) APPLICABLE VEHICLES: 2020-2021 Toyota Highlander CONDITION: This Tech Tip applies to 2020-21 model year Highlander “GAS” with AWD system ONLY. Some customers may complain of leak/fluid from under vehicle or on driveway/garage floor. This may be...

Please see Tech Tip T-TT-0650-21 APPLICABLE VEHICLES: 2021 Toyota Highlander 2021 Toyota Highlander Hybrid 2021 Toyota Sienna Hybrid CONDITION: Some vehicles equipped with Premium Audio systems may experience an inoperative condition that consists of displaying a “Loading…” then a blank...

If you run across a 2011 Toyota Highlander with various problems like the combination meter, trans shifting, and even the radio, then please check the passenger side kick panel for any corroded connectors. This would be due to water intrusion.

*** Toyota has issued a fix for this noise in T-SB-0048-22. Please see this Post here. *** If you have a 2021 Toyota Highlander with a whistle noise starting around 45mph, then you may want to replace the hood seal. Allegedly there us a new design but will still have the old part number. You...

If you run across a 2019 Toyota Highlander and the customer concern is that the rear air conditioning doesn't work, check the rear a/c lines underneath the vehicle (possibly covered by foam or under the splash shield) as a previous technician may have pinched the line when they lifted the vehicle.

Please see T-SB-0025-18 Revision 2 (Link Needed) Toyota Entune Updates Free via Download Applicability: 2016 - 2018 4Runner 2016 - 2017 Camry, Camry Hybrid, Sienna 2016 - 2018 Highlander REVISION NOTICE: June 28, 2021 Rev2 Applicability has been updated to include 2016 model year 4Runner...

Please see Tech Tip T-TT-0655-21 APPLICABLE VEHICLES: 2020-2021 Highlander 2020-2021 Highlander Hybrid 2019-2021 RAV4 2019-2021 RAV4 Hybrid CONDITION: Some vehicles equipped with Premium Audio may experience continuous rebooting after performing a software update. RECOMMENDATIONS: Please...