2016

Some 2016 model year iM vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code (DTC) P2820 present, indicating a Pressure Control Solenoid (shift solenoid valve SLP) Performance condition. The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been...

Some 2016-2018 Toyota Tacomas may exhibit a squeak or rattle noise from the FR RH Body Mount Bushing when driving over uneven roads or bumps. Make sure to confirm that noise is coming from RH FR (No.1) Body Mount Bushing before proceeding with repair. See Tech Tip 0490-18 This is what you...

Some 2016 – 2018 model year Tacoma Double Cab 4WD vehicles equipped with a BD22 rear differential may exhibit a whine type noise from the rear of the vehicle. This condition may occur while driving around 50 mph at constant speed, slight acceleration, or slight deceleration and may be caused by...

Some 2016 – 2018 model year Tacoma 4WD vehicles may exhibit a cyclical groaning or grinding noise coming from the front differential in 2WD that is not present during 4WD operation. Follow the Repair Procedure in bulletin T-SB-0011-18 to address this condition. R & R Front Differential - New...

Toyota is currently conducting an investigation for the 2016+ Toyota Tacoma Instrument Cluster Issues. Your local Dealer may contact you and request you to bring your Tacoma for study participation. Doing so will help other Tacoma Owners in future repair efforts. See this Post and the video...

*** The newest TSB information can be found here. *** Some 2016 – 2019 model year Mirai vehicles may exhibit a warning message, "FC malfunction, return vehicle to dealer for service." This message is accompanied by Diagnostic Trouble Code (DTC) P1DEF (450 FC Stack Performance). The Fuel Control...

You can check the status of any Recall on your Toyota here. Subject: Special Service Campaign H0X 2016 – 2017 Model Year Toyota Mirai EV Control ECU Software Update Condition: The subject vehicles are voluntarily equipped with an event data recorder (EDR). The EDR only collects, stores, and...

You can check the status of any Recall on your Toyota here. Subject: Safety Recall H0U Certain 2016 Model Year Prius Vehicles Inverter Assembly Replacement On October 18, 2017, Toyota filed a Defect Information Report with the National Highway Traffic Safety Administration (NHTSA) informing...

If you have a 2016-2018 Toyota Tacoma and are experiencing a brake vibration (pulsation) especially in the rear, check the diameter on the axle hub to drums. They may not be centering. Your Tacoma may have a bad axle due to tolerances. You may also see that the drum looks overheated. We have...

If you have a 2015-2016 Toyota Prius with a concern of a rapid clicking noise on the left front side, usually when braking and turning slightly, then you may have a bad CV axle in need of replacing. Listen hear at the video around the 16 second mark....

Some 2016 – 2017 model year Prius and 2017 model year Prius Prime vehicles may exhibit a “Grille Shutter Inoperative, Please See Dealer” message on the combination meter and/or a MIL “ON” condition with Diagnostic Trouble Code (DTC) P05A072 (Active Grille Air Shutter “A” Actuator Stuck Open) set...

If you have a 2016-2017 Toyota Rav4 with a blown 7.5 amp IG3 fuse and/or a no charging condition (dead battery) then check the Non Dynamic Cruise connector for corrosion. It's can be accessed behind the bumper, drivers side. May also cause codes P0500 or U0129.

Some 2016 – 2019 model year Prius vehicles equipped with a NiMH HV battery may exhibit one or both of the following conditions after repeated driving on long downhill slopes or while driving in high ambient temperatures, then turned off for approximately 1 – 2 hours, and restarted: *When...

If you have a 2016-2017 Toyota Tacoma with the 2GR-FKS engine, you may want to keep an eye out for any engine coolant loss. We have seen a few coolant leaks from porous blocks around the engine mounts. Here is what a few bad ones look like with a few good ones following those...

If you run across this code on a Toyota Tundra, check and see if the customer is using a non OEM phone charger (like a cheap one from a gas station), these can be the cause of this code. DTC B1868 Short in Knee Airbag(P side) Squib Circuit (to +B)

Some 2016 – 2018 model year Prius, 2017 – 2018 model year Prius Prime, 2018 model year Camry Hybrid, and 2019 model year Avalon Hybrid vehicles may exhibit an intermittent condition where it is difficult to refuel. This condition may be caused by the fuel filler door not opening completely, or...

Recall Letter You can check the status of any Recall on your Toyota here. Subject: Safety Recall H0M – Remedy Notice 2016 Avalon HV and 2016 Camry HV Front Drive Shaft Replacement Condition: The front drive shaft assembly in the involved vehicles may have been misassembled. This could cause...

Recall Letter You can check the status of any Recall on your Toyota here. Subject: Safety Recall H0K -Remedy Notice 2016 Model Year Toyota Tundra vehicles Incorrect Passenger Side Knee Airbag Fasteners Background: On June 29, 2017, Toyota filed a Defect Information Report (DIR) with the...

Recall Letter You can check the status of any Recall on your Toyota here. Subject: Safety Recall G06 – Remedy Notice One 2016 4Runner One 2017 GX460 Passenger Air Bag Booster Tablets Background: On December 21, 2016, Toyota filed a Noncompliance Information Report (NCIR) with the National...