hybrid

  1. MG

    2006-2020 Toyota Hybrid Models HV Battery Cooling System Maintenance T-SB-0062-20 Revision 1

    Please see T-SB-0062-20 Revision 1 (Link Needed) REVISION NOTICE: October 14, 2020 Rev1: The HV Battery Intake Filter Applicability has been updated. Any previous printed versions of this bulletin should be discarded. Introduction: Some 2004 – 2020 model year Hybrid vehicles may exhibit an...
  2. MG

    2020 Toyota Models DTC B15A8** - DCM System Internal Failure T-TT-0572-19 Revision 3

    Please see T-TT-0572-19 Revision 3 CONDITION: Some 2020 model year Camry, Camry HV, RAV4, RAV4 HV, and Corolla Hatchback vehicles equipped with a DCM may exhibit a B15A8** DTC (most likely B15A804) in history during PDS. This DTC can be triggered during the manufacturing and/or shipping...
  3. MG

    2018 Toyota Camry and Camry Hybrid Steering Wheel Requires Increased Effort and/or Exhibits Reduced Return to Center T-SB-0028-22

    Please see T-SB-0028-22 (Link Needed) Introduction: Some 2018 model year Camry and Camry Hybrid vehicles may exhibit a condition in which the steering wheel requires increased effort and/or exhibits reduced return to center. The steering wheel may exhibit a slight resistance at certain points...
  4. MG

    2021-2022 Toyota Hybrids Under Floor Wire Harness for Motor Generator - Connector Cover has Missing or Damaged Appearance Tech Tip T-TT-0690-22

    *** This Tech Tip was in reference to this situation... *** Please see Tech Tip T-TT-0690-22 (Link Needed) CONDITION: On some 2021-2022MY Highlander HV, RAV4 HV, RAV4 Prime and Venza models, the connector cover for the Under Floor Wire Harness for the Rear Motor Generator may have the...
  5. MG

    2019-2021 Toyota Models Smart Key Immobilizer Reset and Add/Remove Key T-SB-0064-18 Revision 2

    Please see T-SB-0064-18 Revision 2 REVISION NOTICE: June 03, 2020 Rev2: Applicability has been updated to include 2021 model year Avalon, Avalon Hybrid, Corolla Hatchback, RAV4, RAV4 Hybrid, Corolla, Corolla Hybrid, Highlander, Highlander Hybrid, Mirai, RAV4 Prime, Sienna Hybrid, and Venza...
  6. MG

    2022 Toyota Tundra Head Unit Activation Process After Replacement T-TT-0674-21

    Please see T-TT-0674-21 CONDITION: After replacing the head unit on 2022 model year Tundra and Tundra HV vehicles, the head unit must have the VIN synchronized with the cloud to prevent the server from blacklisting the new head unit. Please follow the recommendations below to properly perform...
  7. OishiiJPN

    2019-2021 Toyota Rav4 Hybrid MIL ON With DTCs P0AA649 and/or P1C8049 or AM Radio Static/Distortion T-SB-0026-22

    Please see T-SB-0026-22 (Link Needed) Introduction: Some 2019 – 2021 model year RAV4 Hybrid vehicles may exhibit a MIL ON condition with one or both of the following Diagnostic Trouble Codes (DTCs) stored: * P0AA649 (Hybrid/EV Battery Voltage System Isolation Internal Electronic Failure) *...
  8. MG

    2015-2018 Toyota Camry and Avalon Hybrids ABS Brake Warning Light On T-SB-0098-21

    *** This condition is now covered under a Toyota Warranty Extension. Please see CUSTOMER SUPPORT PROGRAM 21TE03 *** Please see T-SB-0098-21 Introduction: Some 2015 – 2017 model year Camry Hybrid and 2016 – 2018 model year Avalon Hybrid vehicles may exhibit a condition where the brake, ABS...
  9. MG

    2011-2013 Toyota Highlander Hybrid ABS Brake Warning Light On T-SB-0097-21

    *** This condition is now covered under a Toyota Warranty Extension. Please see CUSTOMER SUPPORT PROGRAM 21TE03 *** Please see T-SB-0097-21 Introduction: Some 2011 – 2013 model year Highlander Hybrid vehicles may exhibit a condition in which the brake, ABS, and/or TRAC warning lights are on...
  10. OishiiJPN

    2022 Toyota Tundra and Tundra Hybrid Rear Axle Shafts may separate from vehicle during driving Recall 22TA05

    Please see Recall 22TA05 Check here to see if this Recall applies to your Toyota vehicle 2022 Model Year Tundra and Tundra Hybrid Vehicles Rear Axle Shafts May Separate from Vehicle During Driving On June 23, 2022, Toyota filed a Defect Information Report (DIR) with the National Highway...
  11. MG

    2016-2018 Toyota Rav4 Hybrid Headlamp Durability Enhancement T-SB-0002-22

    Please see T-SB-0002-22 (Link Needed) Introduction: Some 2016 – 2018 model year RAV4 Hybrid vehicles may exhibit a condition in which the halogen low beam headlamp bulb lifetime is shorter than customer expectation. Follow the Repair Procedure in this bulletin to address this condition and...
  12. MG

    2019-2021 Toyota Avalon, Camry and Rav4 Hybrids MIL ON With DTC P019064 T-SB-0047-22

    Please see T-SB-0047-22 Introduction: Some 2019 model year Avalon Hybrid, 2018-2019 Camry Hybrid, and 2019- 2021 RAV4 Hybrid vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (OTC} P019064 (Fuel Rail Pressure Sensor "A" Signal Plausibility Failure). The Engine Control...
  13. MG

    2018-2020 Toyota Prius, Rav4 and Sienna Audio Head Unit Software Update (Denso-Ten) T-SB-0051-21

    Please see T-SB-0051-21 SUPERSESSION NOTICE: The information contained in this bulletin supersedes Service Bulletin No. T-SB-0047-20. The aforementioned bulletin is obsolete, and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before...
  14. MG

    2019-2022 Toyota Models DTC U010087 & No Start/ Replaced Engine ECU After Jump Starting T-TT-0694-22

    Please see Tech Tip T-TT-0694-22 Condition: After jump-starting, the vehicle may experience a no-start condition and multiple DTCs including U010087. Upon investigation, it is found that the engine ECU has been damaged and needs to be replaced (Fig 1). In several cases, it was found that the...
  15. MG

    2022 Toyota Highlander, Highlander Hybrid, Tacoma, 4Runner Load Carrying Capacity Modification Label – Illegible Labels Recall 22R1

    Please see Recall 22R1 Check here to see if this Recall applies to your Toyota vehicle On May 6, 2022, Gulf States Toyota, Inc. (GST) filed a Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA) informing the agency of our intent to conduct a...
  16. Lewis

    2019-2021 Toyota Rav4 and Rav4 Hybrid Front Brake Squeal/Squeak Noise T-SB-0001-22

    Please See T-SB-0001-22 Revision 1 Introduction: Some 2019 – 2021 model year RAV4 and RAV4 Hybrid vehicles may exhibit a squeal/squeak noise from the front brakes with light to moderate braking. Follow the Repair Procedure in this bulletin to address this condition. Warranty Information...
  17. OishiiJPN

    2020-2022 Toyota Highlander Hybrid Engine Noise on Acceleration T-SB-0103-21

    Please see T-SB-0103-21 Applicability: 2020-2022 Highlander Hybrid Introduction: Some 2020 – 2022 model year Highlander Hybrid vehicle customers may express a concern of engine noise on acceleration from 0 – 45 mph. Follow the Repair Procedure in this bulletin to address this condition...
  18. OishiiJPN

    2010-2018 Toyota Models Millimeter Wave Radar Sensor - Floor Slope Compensation T-SB-0088-21

    Please see T-SB-0088-21 Introduction: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation Procedure in this...
  19. MG

    2020–2022 Toyota Models Vehicle Stability Control System May Not Default to "On" Recall 22TA03

    Please see Recall 22TA03 2020–2022 Toyota Models Vehicle Stability Control System May Not Default to "On" On April 26, 2022, Toyota amended a previously filed Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA). The amended Noncompliance...
  20. MG

    2020-2021 Toyota Rav4 and Rav4 Hybrid Evaporator Drain Hose Plastic Obstruction T-SB-0007-22

    Please see T-SB-0007-22 Applicability: 2020-2021 Toyota RAV4, RAV4 HV WMI(s): 2T3, 4T3 (Please see this Post to determine VDS and WMI's) Introduction: Some 2020 – 2021 model year TMMC and TMMK built RAV4 and RAV4 Hybrid vehicles may exhibit damp carpeting in the front floor area. This may be...
Top