rav4

Please see T-SB-0002-22 (Link Needed) Introduction: Some 2016 – 2018 model year RAV4 Hybrid vehicles may exhibit a condition in which the halogen low beam headlamp bulb lifetime is shorter than customer expectation. Follow the Repair Procedure in this bulletin to address this condition and...

Please see T-SB-0047-22 Introduction: Some 2019 model year Avalon Hybrid, 2018-2019 Camry Hybrid, and 2019- 2021 RAV4 Hybrid vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (OTC} P019064 (Fuel Rail Pressure Sensor "A" Signal Plausibility Failure). The Engine Control...

Please see T-SB-0022-22 Revision 1 SUPERSESSION NOTICE: The information contained in this bulletin supersedes Service Bulletin No. T-SB-0067-20. The Introduction, Warranty Information, Parts Information, and Required Tools & Equipment sections have been updated.  The Production Change...

Please see T-SB-0027-22 (Link Needed) Introduction: Some 2021 – 2022 model year RAV4 Prime vehicles equipped with a Blind Spot Monitor (BSM) may exhibit a BSM outer mirror indicator that stays on without a vehicle in the detection area after being passed by a vehicle. Follow the Repair...

Please see T-SB-0051-21 SUPERSESSION NOTICE: The information contained in this bulletin supersedes Service Bulletin No. T-SB-0047-20. The aforementioned bulletin is obsolete, and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before...

Please see T-SB-0042-22 Revision 1 Introduction: Some 2021 model year RAV4 Prime vehicles may exhibit a short humming/buzzing noise upon startup (Ready ON) with the compressor on. Follow the Repair Procedure in this bulletin to address this condition. Warranty Information: Reprogram Air...

Please See T-SB-0001-22 Revision 1 Introduction: Some 2019 – 2021 model year RAV4 and RAV4 Hybrid vehicles may exhibit a squeal/squeak noise from the front brakes with light to moderate braking. Follow the Repair Procedure in this bulletin to address this condition. Warranty Information...

Please see Recall 22TA03 2020–2022 Toyota Models Vehicle Stability Control System May Not Default to "On" On April 26, 2022, Toyota amended a previously filed Noncompliance Information Report (NCIR) with the National Highway Traffic Safety Administration (NHTSA). The amended Noncompliance...

If you run across a 2019-2020 Toyota Rav4 with the horn blowing continuously even when the button isn't pressed then look for corroded connectors in the passenger/driver side kick panels and water intrusion. This will most likely be caused by the roof rails...See this post and See this Post...

Please see T-SB-0007-22 Applicability: 2020-2021 Toyota RAV4, RAV4 HV WMI(s): 2T3, 4T3 (Please see this Post to determine VDS and WMI's) Introduction: Some 2020 – 2021 model year TMMC and TMMK built RAV4 and RAV4 Hybrid vehicles may exhibit damp carpeting in the front floor area. This may be...

If you run across a 2019-2021 Toyota RAV4 and the customer concern in that the cabin doesn’t stay warm or the outlet temperature get cool when sitting at a stoplight, then check the coolant valves for staying open. Especially the one just under the transmission shift cable (16671-24020...

If you run across a 2019 Toyota Rav4 with a complaint of the wipers not turning off, then you will want to inspect the wiper relay assembly located on the drivers side for water intrusion. We have found corrosion on the connectors (A5 and A6). The wipers would continue to run with the ignition...

Please see Consumer Advisory Support 21TG01 APPLICABLE VEHICLES: Overview: During a recent investigation of reported battery fires in 2013-2018 RAV4 vehicles with gasoline engines (excluding hybrid models), Toyota discovered that many non-Toyota retailers and others who sell or install...

If you run across a 2016ish (+,-) Toyota Rav4 and its blowing the 7.5 amp ecu-ig no.3 fuse, them you may want to check the AD1 connector located under driver side headlight that would power the front bumper sonar sensors and millimeter wave radar if it was equipped. Check for corrosion causing...

If you run across a 2020-2021 Toyota model with remote start and the customer concern is that the vehicle stays running after opening the front door (remote start), then you may want to replace the DCM.

Please see Tech Tip T-TT-0678-21 CONDITION: Some 19CY LG DCM equipped vehicles may not be able to complete the firmware update due to not having an active account or waived services during the trial. Follow the steps below to enable “Temp DCM Activation”. RECOMMENDATIONS 1. Confirm the...

OBSOLETE NOTICE October 15, 2021: This bulletin is no longer applicable and is now obsolete Please see T-SB-0002-18 Revision 1 Applicability: 2018 Toyota Corolla, Prius C, RAV4, RAV4 HV Introduction: Some customers may complain of the inability to use certain functions of the...

Oil pressure low warning message on dash without codes. Data list all in specification for oil pressure readings. You may want to check for any corroded wires in the drivers side kick panel due to a water leak.

Please see T-SB-0089-21 Revision 2 REVISION NOTICE: June 07, 2022 Rev2 The Introduction and DCM Reset and Firmware Update Procedure sections have been updated. April 11, 2022 Rev1 The Applicability, Introduction, and DCM Reset and Firmware Update Procedure sections have been updated. Any...

If you have a 2020 Rav4 hybrid AWD (smart key) and you programmed a new key but now both keys allow the vehicle to ready up and neither key will lock or unlock the vehicle, go do the ecu communication registration for id code box and steering lock. This should fix it, if not then reseed the...