highlander

Special Service Campaign SSC 19TC04 Letter Condition: The involved vehicles are equipped with an engine oil cooling system. The oil cooling system could experience a small leak due to a manufacturing issue. If a vehicle is continuously operated with this condition, it may result in abnormal...

If you get a customer concern that the maintenance light wont reset please check the message on the cluster again to make sure it reads "Engine Maintenance Required". If that is the case, please pull codes and if you see code P268115 Engine Coolant Bypass Valve Circuit Short to Battery or Open...

REVISION NOTICE January 17, 2020 Rev1: The Introduction section has been updated. 2019 Toyota Highlander, Highlander Hybrid Some 2019 model year Highlander and Highlander Hybrid vehicles equipped with JBL audio may exhibit inoperative text message playback, navigation voice prompts, and/or...

Warranty Enhancement Letter ZJC Subject: Warranty Enhancement Program – ZJC 2017-2018 Model Year Highlander 2017-2018 Model Year Sienna Extension of Warranty Coverage forr UA80 Transmission In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Customer...

If you run across one of the Highlander with an overcharging condition (which you probably already changed the alternator to fix and it didn't) then you'll want to check EB2 connector for corrosion. It is located near the battery and Fuse block at the left front.

Some 2017 – 2019 model year Highlander HV vehicles may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): P0301 – Cylinder 1 Misfire Detected P0302 – Cylinder 2 Misfire Detected P0303 – Cylinder 3 Misfire Detected P0304 – Cylinder 4 Misfire Detected...

To: All Toyota Dealer Principals, General Managers, Service Managers, and Parts Managers CUSTOMER SUPPORT PROGRAM ZKG LETTER ---- PLEASE READ Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied...

Some 2014 – 2018 model year Highlander and Highlander Hybrid vehicles may exhibit one or more of the following conditions. * Various drivability concerns * Low or no fuel pressure * Diagnostic Trouble Codes (DTCs) (Including but not limited to P1603, P1604, P1605, P0171, P0300, P0302, P0304...

Please Read CUSTOMER SUPPORT PROGRAM BULLETIN ZKC Subject: Customer Support Program / Warranty Extension ZKC 2008-2010 Model Year Highlander Hybrid Vehicles Coverage for Brake Actuator Assembly and Brake Booster Pump Assembly In our continuing efforts to ensure the best in customer...

*** The warranty for this concern has been extended. Please see Customer Service Program ZKC for warranty details here... Some 2008 – 2010 model year Highlander Hybrid vehicles may exhibit a condition where the brake, ABS, and/or TRAC warning light(s) are on and/or a Check VSC message displays...

If you run across a Toyota Highlander with a 2GR-FKS and have a code like P219E00, then go ahead and perform the cylinder compression test as well as the leak down test. These two tests may result in normal readings (compression 200psi, leakdown 2-5%) but we are seeing is that the intake valve...

Some 2017 – 2018 model year Highlander Hybrid vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code (DTC) P3190 (Poor Engine Power). This may occur when operating the vehicle in high altitude and high temperature conditions. The engine control module/ECM (SAE Term: Powertrain...

*** This condition has a Transmission Warranty Extension called ZJC. Please see here... Please see T-SB-0160-18 Revision 1 Applicability: 2017-2018 Toyota Highlander and Sienna Transmission(s): 8AT REVISION NOTICE: May 11, 2021 Rev1 The Introduction, Required Tools & Equipment, and Repair...

Some 2014 – 2018 model year Highlander and Highlander HV vehicles may exhibit a condition where the power back door (PBD) makes a squeak noise while the door is opening or closing. Follow the Repair Procedure in bulletin T-SB-0127-18 to address this condition. This repair is covered under the...

2018 Camry 2017 - 2018 Highlander 2017 - 2018 Sienna 2016 - 2018 Tacoma Some 2016 – 2018 model year Tacoma, 2017 – 2018 model year Sienna, Highlander, and 2018 model year Camry vehicles equipped with a 2GR-FKS engine may exhibit an engine oil leak from the cam sensor bolt hole(s). Follow the...

2014 - 2016 Highlander, Highlander HV 2013 - 2016 RAV4 2010 - 2016 Sienna Some North American produced RAV4, Highlander, Highlander HV, and Sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. Upon closer inspection it may be noticed...

Recall Letter You can check the status of any Recall on your Toyota here. Subject: Safety Recall J0K – Remedy 2017 Model Year Sienna and Tacoma Vehicles 2018 Model Year Camry and Highlander Vehicles Vacuum Pump Recall On April 3, 2018, Toyota filed a Defect Information Report (DIR) with the...

Please see T-SB-0072-18 Revision 1 Introduction: Some 2014 – 2018 model year Highlander vehicles may exhibit a vibration from the front brakes during light application of the brake pedal at highway speeds .Follow the Repair Procedure in bulletin T-SB-0072-18 to address this condition. R & R...

You can check the status of any Recall on your Toyota here. Subject: Owner Notification - J0E 2018 Model Year Highlander LE FWD 2018 Model Year Highlander LE AWD 2017 Model Year Tacoma TRD Pro with Manual Transmission Vehicle Window Sticker (Monroney Label) Condition: Due to a clerical error...

2018 Camry 2017 Highlander 2017 Sienna 2016 - 2017 Tacoma Some 2016 – 2017 model year Tacoma, 2017 model year Sienna and Highlander, and 2018 model year Camry vehicles equipped with a 2GR-FKS engine may exhibit a chirping noise from the high-pressure fuel pump. Follow the Repair Procedure in...